Finned cooling tubes are used to improve heat transfer efficiency. Usually, fins are added to the surface of the heat transfer tubes to increase the outer surface area of ​​the heat transfer tubes, thereby achieving the purpose of improving heat transfer efficiency. Such heat transfer tubes are called finned tubes.

The working principle of the finned tube radiator is to use the refrigerant to cool the air, or the heat medium to heat the air.

When heating is required, the finned tube radiator can use high temperature water, steam or high temperature heat transfer oil to heat the air.

When cooling is required, finned tube radiators can use low temperature water, such as chilled water, to cool the air.

In the process of inspection of laser welded finned tube, it is necessary to check whether there are deposits, coking, scales, etc.

At the same time, it is also necessary to check whether the bonding between each finned tube and the rubber gasket is tight, and whether the rubber gasket itself is intact, so as to avoid leakage caused by degumming and damage of the rubber gasket.

Double pipes should be buried for pile diameters of 0.6-0.8m; three pipes should be buried for pile diameters of 0.8-2.0m; four pipes should be buried for pile diameters above 2.0m, and three pipes can be buried for pile foundations according to the specific conditions of Chifeng Bridge.

The acoustic wave detection tube should adopt steel pipe, plastic pipe or steel corrugated pipe, and its inner diameter should be 50-60mm.

The joints of the detection tubes should be smoothly transitioned, the nozzles should be more than 100mm higher than the top of the pile, and the heights of the nozzles of each detection tube should be the same, the lower end of the tube should be closed, and the upper end should be covered.

The compression nut and the upper and lower guide rods of the laser welded finned tube should be lubricated frequently with lubricating grease.

Special personnel shall be responsible for the adjustment of each instrument, and the operating procedures shall be strictly followed for operation and maintenance.

laser welded finned tubes

Every time you re-press the finned tube, you must pay attention to the scale position when you pressed it last time, and don’t over-press the rubber gasket, so as to reduce the service life of the gasket.

Before the finned tube is tested on site, the delay time from the launch of the acoustic wave detector to the receiving system is determined.

And calculate the sound time correction value. When measuring, the transmitting and receiving probes should be raised and lowered synchronously at the same elevation or with a fixed height difference.

The measurement point distance is 40cm, and it will be re-densified to 20cm when abnormalities are found.

When replacing the rubber gasket of the finned tube, the section must be renewed to avoid uneven gaps between the sheets and affect the heat transfer effect.

The laser welded finned tube were selected for proper emission voltage and amplifier gain, and then kept constant during the test. Display and record the time history curve of the received signal in real time.

Combine multiple finned tubes with two as a detection profile, and complete the detection of multiple profiles respectively.

Laser welding finned tube is processed by laser welding machine. Laser welding is a welding method that irradiates a high-intensity laser beam onto the metal surface. Through the interaction of the laser and the metal, the metal absorbs the laser light and converts it into heat, melting the metal to form a cooling crystal. Laser welding machine is the most advanced laser welding equipment for finned tubes. Because the welding process is fully automatic and mechanical, the scientific and technological content and quality of laser welding finned tubes are superior to traditional cooling tubes.

The laser welding finned tube has a fully automatic welding process, saving manpower costs; secondly, the laser welding fin is firm, strong, and the test with high tensile strength is qualified. Laser welding is more efficient.

20

Advantages of laser welded finned tube

  1. The laser welding finned tube (finned tube) fin machine has a high degree of automation, and the welding of the fin to the tube and the winding of the tube are synchronized
  2. 100% welding rate, laser welding finned tube and fins are strong, the welding strength exceeds 600MPa.
  3. The precision of laser welding tube finishing machine is up to 0.05mm
  1. 0 contact resistance, achieve high efficiency of heat transfer of spiral finned tube by laser welding.
  2. Save production costs. The laser welding finned tube (finned tube) has a smaller fin spacing, less than 2.5mm. Compared with the high frequency welded spiral (spiral) finned tube, the heat transfer area is increased by about 50%, which makes the material cost Reduced, volume reduced heat exchanger.
21
22

The advantages over conventional MAG / HF welding are of decisive importance. The complete connection between the fin and the base tube brings excellent heat transfer, and the thermal performance of the fin tube is increased by 2.5 times. Continuous welding prevents the notch effect, thereby avoiding the formation of v-corrosion and cracks under the condition that the finned tube may swing. The heating of base metals during welding is low and the travel speed is up to 20m / min. Minimize the heat affected zone in the base tube. 

Power Plants

  • Cooling towers or cooling water recooling plants with dry, dry / wet or wet operation
  • Flue gas cooling and heating in flue gas desulfurisation scrubbers (FGD) and nitrogen removing plants (DENOX)

 Chemical Industry

  • Heat exchangers of all kinds for cooling and heating of liquids and gases
  • Heat exchangers tor nitric acid (HNO3) plants, e.g. for the fertilizer industry

 Heat Recovery Plants

  • Flue gas coolers

 Heating Industry

  • Primary heat exchangers in gas heating boilers
  • Secondary heat exchangers for domestic water heating in condensing boilers

 General Engineering

  • Heat exchangers for gas cooling of industrial furnaces
  • Heat exchangers for tank heating
  • Oil coolers for vacuum plants, ship plants, pumps etc.
  • Heat exchangers for oil preheating

Dimensions

  • Tube outside diameter 8.0–50.0 mm
  • Fin outside diameter 17.0 –80.0 mm
  • Fin pitch 5 –13 fin/inch
  • Fin height 5.0 –17 mm
  • Fin thickness 0.4 – 1.0 mm
  • Maximum tube lengths 12.0 m
Fin Type:
Laser welded finned tube
 Tube Material: 
steel, aluminum, copper, titanium etc.
 Fin Material:
Copper, aluminum

 

23

Pre-sales service

Inquiry and consulting support.

Sample testing support.

Visit our factory

Company name:   Cangzhou Datang Steel Pipe Co., Ltd

Address: Cangzhou City, Hebei Province, China

Contacts: Howie Li

Whatsapp Number: 0086 15530722107

Email: datangfintube@gmail.com

Looking forward to receiving your inquiry, I will offer you a very reasonable price.

Any questions, I will reply you within 24 hours.